Product ID:RESINOOO OUTBOUND RESIN BONDED ABRASIVE PRODUCTS
MSDS Date:03/21/1995
FSC:5130
NIIN:00D004049
MSDS Number: BXVVZ

NORTON CO

1 NEW BOND ST
WORCESTER, MA 01606-0008
US

Emergency Phone: 508-795-2690

Info Phone: 508-795-2690

Cage: 44197

NORTON CO

15008 WORCESTER, MA 01606-0008 US

Telephone: 508-795-2690/508-795-5000

Cage: 44197

ZIRCONIUM OXIDE

CAS: 1314-23-4

RTECS: ZH8800000

Fraction By Weight: 30-50%

ALPHA-ALUMINA (ALUMINUM OXIDE) (SARA 313)

CAS: 1344-28-1

RTECS: BD1200000

Fraction By Weight: 40-90%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9495

CURED PHENOLIC RESIN

Fraction By Weight: 3-12%

FIBERGLASS (FIBROUS GLASS)

CAS: 65997-17-3

Fraction By Weight: <10%

OSHA PEL 5 MG/M3 RESP DUST

ACGIH TLV: 10 MG/M3 (<7MICRONS)

SILICON CARBIDE

CAS: 409-21-2

RTECS: VW0450000

Fraction By Weight: 80-90%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9495

CALCIUM OXIDE

CAS: 1305-78-8

RTECS: EW3100000

Fraction By Weight: 1-5%

OSHA PEL 5 MG/M3

ACGIH TLV: 2 MG/M3; 9495

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: .001-1%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST;9495

BARIUM SULFATE (MFR SAYS IS SARA 313 REPORTABLE)

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 1-7%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9495

FLUORIDES

Fraction By Weight: 2-10%

SULFATES AND SULFIDES

Fraction By Weight: 1-10%

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION. NO KNOWN HEALTH EFFECTS FROM
INGESTION, BUT IT IS NOT RECOMMENDED. CHRONIC: PROLONGED OR
REPEATED EXPOSURE TO DUST MAY AFFECT BREATH ING CAPACITY. THIS
PRODUCT CONTAINS A CHEMICAL, CRYSTALLINE SILICA, KNOWN TO STATE OF
CA. TO CAUSE CANCER/BIRTH DEFECTS.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS LISTED BY NTP AS
AN ANTICIPATED CARCINOGEN AND IARC AS A 2A SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES-REDNESS, TEARING, DISCOMFORT.
SKIN-REDNESS, ITCHING, DISCOMFORT. INHALED-SNEEZING, COUGHING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALED-REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
BREATHING STOPPED. GET IMMEDIATE MEDICAL ATTENTION. SKIN-WASH
AFFECTED AREAS WITH SOAP & WATER. OBTAIN MEDICAL ASSISTANCE.
EYES-WASH WITH LO TS OF WATER. OBTAIN 1ST AND MEDICAL ASSISTANCE,
IF NEEDED. INGESTED-CALL A POISON CONTROL CENTER, HOSPITAL
EMERGENCY ROOM OR PHYSICIAN IMMEDIATELY.

Extinguishing Media:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: USE MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTETCIVE GEAR.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:FOLLOW NORMAL CLEAN-UP PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:ALWAYS HANDLE AND STORE WHEELS IN A
CAREFUL MANNER. ALWAYS VISUALLY INSPECT ALL WHEELS BEFORE MOUNTING.
ALWAYS USE MOUNTING BLOTTERS.
Other Precautions:ALWAYS CHECK MOUNTING FLANGES FOR EQUAL AND CORRECT
DIAMETER. ALWAYS BE SURE WORK REST IS PROPERLY ADJUSTED. ALWAYS USE
A SAFETY GUARD COVERING AT LEAST ONE-HALF OF THE GRINDING WHEEL.

Respiratory Protection:RESPIRATORS ARE REQUIRED WHEN AIRBORNE
CONTAMINANT LEVELS EXCEED THE TLV(S). ENGINEERING OR ADMINISTRATIVE
CONTROLS ARE PREFERRED METHODS OF CONTROLLING EXPOSURE.
Ventilation:HANDLE IWTH ADEQUATE VENTILATION. SEE OSHA 29 CFR 1910.94
(VENTILATION) AND 29 CFR 1910.1000 (AIR CONTAMINANTS).
Protective Gloves:NONE SPECIFIED BY MANUFACTURER.
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS.
Other Protective Equipment:USE OF THIS PRODUCT MAY CREAT ELEVATED SOUND
LEVELS. HEARING PROTECTION SHOULD BE WORN IAW 29 CFR 1910.134.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
TSCA-ALL COMPONENTS OF THIS PRODUCT ARE REGISTERED UNDER THE REGULAIONS
OF THE TOXIC SUBSTANCE CONTROL ACT (TSCA).

HCC:N1
Appearance and Odor:SOLID ARTICLE; ODORLESS.

Stability Indicator/Materials to Avoid:YES
ACIDS OF ALL TYPES WITH A PH < 4.0.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN USE, DUST. DECOMPOSITION PRODUCTS;
TRACE AMOUNTS OF PHENOL AND/OR FORMALDEHYDE, MAY BE GENERATED.

Waste Disposal Methods:USE STANDARD LANDFILL METHODS CONSISTENT WITH
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS. PRODUCTS WITH
LISTED FLUORIDES MAY HAVE SLIGHTLY SOLUBLE FLUORIDE SWARF. NORTON
CO. HAS DEVELOPED A WHEEL RECYCLING PROGRAM-INTERESTED-CALL:
508-795-5000.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.